1、1 适用范围 本方案仅适用于XX炼油乙烯项目芳烃联合装置的工艺管道的试压。2 编制依据a） 工业金属管道工程施工及验收规范GB50235-97；b） 石油化工有毒、可燃介质管道工程施工及验收规范SH35012002；c） 中国石化工程建设公司的设计文件;d） 石油化工施工安全技术规程SH3505-1999；e） FCC制定并实施的符合GB/T190012000 idt ISO9001：2000质量管理体系要求标准的质量手册；f） FCC制定并实施的符合GB/T240011996 idt ISO14001:1996环境管理体系 规范、OHSAS18001:1999职业安全健康管理体系规范、国家经2、贸委职业安全卫生管理体系试行标准以及中国石油化工集团公司Q/SHS0001.52001施工企业安全、环境与健康管理规范的安全、环境与健康管理手册（即HSE手册）。3 工程概况3.1 工程简述1） xx炼油乙烯项目芳烃联合装置以直馏石脑油、加氢裂化重石脑油及乙烯裂解汽油为原料，生产对二甲苯和苯等芳烃产品。本联合装置由石脑油加氢（1510）、连续重整（1520）、抽提蒸馏(1530）、二甲苯分馏(1540)、吸附分离(1560）、歧化（1555）、异构化（1570）七个工艺装置及相应公用工程部分组成。2） xx炼油乙烯项目芳烃联合装置共有工艺管线200公里，整个芳烃联合装置划分为13个施工区域，分3、别为:街区(1500）、预加氢重整炉反应区（1501）、预加氢重整分离区（1502）、抽提蒸馏区（1503）、预加氢重整压缩区(1504）、二甲苯炉区(1505）、二甲苯分馏区(1506）、吸附分离1区（1507）、吸附分离2区(1508）、歧化、异构化炉反区（1509）、歧化区(1511)、异构化区（1512）、歧化、异构化压缩机区（1513）。该套装置工艺管线材质主要包括20#、L245、20R、20G、15CrMoG、A691 11/4Cr CL22、0Cr18Ni9、0Cr17Ni12Mo2、Q235B+Zn等。3） 根据管线的设计参数及介质情况，共分748个试压系统.工艺管线分为水压4、试验和气压实验，水压最大试验压力为10。24MPa 。气压试验见xx炼油乙烯项目芳烃联合装置工艺管道气压施工方案。芳烃联合装置的工艺管线可按施工区域划分成若干个试压系统进行试压,具体数量如下:l 石脑油加氢（1510)共分96个试压系统l 连续重整(1520）共分126个试压系统l 重整催化剂连续再生装置（1525）共分63个试压系统l 抽提蒸馏区（1530）共分149个试压系统l 二甲苯分馏装置（1540)共分79个试压系统l 甲苯歧化及烷基转移(1550）共分45个试压系统l 苯-甲苯分馏（1555）共分18个试压系统l 吸附分离装置（1560）共分137个试压系统l 异构化装置(15705、）共分35个试压系统4） 除特殊情况及管道表规定外,芳烃联合装置工艺管线试压原则上优先采用水压试验。3.2 工程特点及施工技术关键芳烃联合装置工艺管道材质复杂、试压系统多、试验压力高。试压前必须严格按照试压系统的划分对现场工程实体和试压系统的准备情况进行检查确认;试压过程中应做好安全防护工作，严格执行施工工艺,缓慢、分级升压，分级检查确认。试压后的泻压排放必须缓慢平稳，以确保安全。奥氏体不锈钢管线试压用水应保证水中氯离子含量不超过25mg/L。4 施工进度计划4.1 总体安排1） 4月1日4月15日试压前准备工作，试压包及试压方案编制审批，现场试压机具及措施用料准备。2） 4月16日6月30日6、工艺管线试压完,水压试验系统管线积水吹扫干净,系统封闭。3） 7月1日7月7日伴热管线试压完,管内积水吹扫干净4.2 劳动力计划时间2008年4月1日7月7日4月份5月份6月份7月份管 工10405035焊 工4663起重工2442其 他8143020合计246490605 施工方法5.1 施工工序编制试压方案试压系统划分系统检查确认试压前资料确认管线支吊架检查确认试压前试压系统报审安装试压临时线系统上水系统升压系统试压检查系统漏点确认系统泄压漏点整改，确认合格泄压排水相关人员签字确认试压结果报审合格复位吹洗说明： 重点工序 可能出现的工序 5.2 施工工艺5.2.1 技术准备 试验介质及试验7、压力选用根据中国石化工程建设公司提供的管道表中的规定。5.2.2 系统试压流程图的编制系统试压流程图主要根据工艺管线流程图编制，压力等级相同的相连管线可编为一个试压系统.每张系统流程图中应标明本系统所包含的管线号,系统的试验压力，系统中的盲板位置及规格，连接管位置、压力表位置、排放点位置、上水点位置。5.2.3 试压水源 芳烃联合装置的试压用水为装置区内的消防水，现场试压用的临时管线采用该套装置内的非净化风线（PA）、生活水（PW)两条管线.上水泵放在2#管廊的南端。示意图如下：5.2.4 试压盲板准备1） 试验临时盲板根据试压包统计出各种规格和数量后统一在预制厂内制作。2） 具体各种规格临时8、盲板根据统计情况出图进行加工。5.2.5 试压前需具备的条件：a） 由施工技术人员根据设计要求、试压系统划分及周围环境等条件编制切实可行的试压方案；并对试压人员进行试压前的技术交底。b） 试压系统的划分必须依据工艺管道流程图、设计提供的基础数据。c） 检查确认待试压系统内的管线已按照设计文件安装完毕,所有管线支吊架的型式、材质、安装位置正确,数量齐全,紧固程度、焊接质量合格，特别要检查热力管线固定,滑动支吊架的安装质量；d） 施工岗组应按试压系统流程图中所给出的位置和规格安装试压盲板，插入式盲板两侧需加橡胶石棉垫。e） 确认管线焊缝热处理和无损检验工作已经全部完成，且结果合格；f） 确认管线焊9、缝未经防腐涂漆处理；g） 试压用的临时加固措施符合要求，临时盲板安装正确，标志明显，并已经登记备案;h） 待试管道上的安全阀，爆破报警及仪表元件等已经拆下或加以隔离。i） 试验用压力表已经校验完毕，并在有效期内，其精度不得低于1。5级。试压所选压力表的满刻度值为被测最大压力的1。52倍；j） 试压系统内设置的压力表不得少于2块,且应在高点，低点分别设置；k） 试压临时管路按试压流程图确定的位置安装.压力表安装优先考虑系统管路上正式压力表的安装位置，临时压力表安装位置按流程图中标明的位置安装，优先考虑在法兰式盲板处、放空阀处或调节阀位置处临时短管及临时上水线上，不得在正式管路上随意开孔。l） 试10、压水源已经落实.试压用水采用洁净水，奥氏体不锈钢管线试压用水须检验氯离子含量不超过25 mg/L，并由检验部门出具水质分析报告；5.2.6 试压用盲板已加置完善，且盲板厚度符合规范要求。试压盲板厚度的计算=D内 3P/16SE 式中：D内：法兰垫片内径（mm） P：试验压力（Mpa） SE：0.75材料的屈服强度，当选用ASTM A516 GR70：屈服强度为262MPa。 ：盲板厚度（mm）5.2.7 试压前检查管道系统试压前应由施工技术人员和试压技术人员对下列资料进行汇总核对：1) 试压系统流程图2) 试压系统单线图3) 试压系统内管道的焊接工作记录4) 试压系统内管道的无损检测报告5) 11、设计变更及材料代用文件6) 试压系统管道安装内洁检查记录7) 试压系统管道试压条件检查确认单8) 试压系统内施工记录(含管道补偿器安装记录、安全附件安装检查记录、热处理记录、管道强度严密性试验记录）5.2.8 试压前现场条件确认管道系统试压前，由试压技术人员对以下条件进行确认:1） 管线全部按设计文件安装完毕;2） 管道支吊架的型式、材质、安装位置正确，数量齐全，螺栓紧固，焊接质量合格；3） 焊接工作已全部完成；4） 焊缝及其它检查位置不应隐蔽；5） 试压及临时加固措施安全可靠，临时盲板位置正确，标记明显；6） 试压用的检测仪表必须经计量合格，量程为试验压力的1.52倍，精度等级1。5级；7）12、 试压泵已准备就绪，且与机泵相连的试压临时管线已安装完成。8） 合金钢管道系统的PMI检测工作全部完成并合格。5.2.9 资料审查及现场条件确认后，由试压技术员向项目质检站报审，由项目质检站检查合格后向SEI报审，由SEI向监理报审,同时通知IPMT项目组，并由IPMT通知OPMT联合对现场实体进行联合检查确认，在接到允许试压的通知后质检站以书面形式通知作业单位实施试压。5.2.10 水压试验系统流程图：升压泵上水泵待试系统低点放净高点放空高位压力表低位压力表快速接头水槽快速接头和软管快速接头和软管快速接头和水源软管试压工作站图-25.2.11 系统试压:1) 临时管线安装：试压用临时管线可用13、钢管，也可用高强度金属软管或橡胶管.2) 上水：系统经检查合格后，开启高点放空阀门和上水阀门,往系统内注水。3) 排空：系统注水过程中，必须确保高点放空阀为打开状态，直到排出的水为柱状。确认系统内不含空气时，关闭放空阀。4) 升压:系统注水完成,检查法兰等连接处无泄漏后，开动升压泵，系统开始升压。升压应分级缓慢进行.同时应在压力表和机泵处各设专人,待达到强度试验压力后，立即关闭机泵,停压10min，检查合格后再降压至设计压力,停压30min进行严密性试验。5) 漏点处理l 当发现系统有泄漏等到不合格情况时，应立即将系统泄压，然后对系统进行整改，合格后重新试压。l 严禁对系统进行带压处理6) 系14、统检查：达到强度试验压力和严密性试验压力后,应沿管线逐一检查焊缝、法兰、阀门等处是否有泄露，并查看压力表，以无降压,无泄漏、无变形为合格。7) 排水:系统试压合格后，应缓慢降压，试压用水应排往附近的地沟，若系统较大,排水时应打开放空阀,防止形成负压.5.2.12 系统封闭1) 试压系统管线试压合格后，及时拆除盲板和临时短管等.盲板拆除时应根据盲板安装记录逐一核对不得漏拆并按附表2填写。盲板安装及拆除由施工员检查确认,记录按序号保管好以备查阅.2) 试压系统管线试压合格后，将所有的仪表元件，安全阀等恢复安装。5.2.13 资料试压完成，填写管道系统安装检查与压力试验记录J407，并请总包单位、监15、理单位、IPMT项目组及OPMT的相关人员签字确认.6 施工组织机构项目经理：曲圣伟安监站李国建技术质量部余奔技术负责：吴中财生产经理：林开明项目副经理：秦少庆供应部田寿辉经营部宁忠工程部严智明项目总工程师：贺汉卫管道公司项目经理：山建国工程师：滕洪工程师：贾胜彪施工作业单位7 质量管理机构和质量保证措施7.1 质量管理机构质检处项目经理：曲圣伟项目总工：贺汉卫安全部：李国建经营部：宁忠供应部：田寿辉技术质量部：余奔工程部：严智明施工作业单位7.2 质量保证措施1） 试压前技术部负责完成试压方案的编制工作,并做好方案交底。2） 试压前由专业公司施工员先行自检，自检合格后，将试压包报检资料交项目16、质检站.3） 试压包报检资料含：- 试压流程图- 单线图- 试压条件确认单- 管道内洁检查记录- 未完尾项一览表（注明未完原因、计划完成时间及处理和检验方法）- 施工记录（管道补偿器安装记录、安全附件安装检查记录、热处理记录、管道强度严密性试验记录、管道焊接工作记录、PMI检验记录）- 探伤报告- 硬度报告注：材质证、阀门试压记录等材料质量证件,统一存放供应部备查)4） 试压泵必须符合公司设备管理程序的要求,并能满足试验压力的要求。5） 不能参与试压的仪表、设备必须拆除或隔离。6） 由于现场实际情况所造成的最终碰头接口焊口，必须进行100射线检测。7） 设计说明中要求地面试压的管道，必须进行临17、时加固以确保管道及支架无变形并经各方确认后方可进行试压.8） 对于无法进行试压的管道，可用100射线检测及100%渗透检测来代替。9） 管道试验压力不得高于系统内阀门的严密性试验压力.10） 试压前对机泵出口的单向阀根据实际情况进行调向后，在流程图中必须注明并挂牌标记，试压结束后及时调整。11） 奥氏体不锈钢管道水压试验时，水中氯离子含量不得超过25PPm.12） 试压盲板标识要明确,并有记录,盲板两端应加双垫。8 HSE管理和控制措施1) 施工人员已经过“安全教育”，并被允许进入现场作业.2) 施工人员已接受技术交底,并明确试压过程中应注意的事项.3) 高空作业，装置区域动火、用电、吊装等作18、业严格执行装置及项目的具体规定。4) 高空检查管道时,必须系挂安全带，吹扫作业应佩戴防噪音耳塞.5) 临时管线焊接应采用与正式管线相同的焊接工艺。6) 试压用水,及管道吹洗排放物严禁就地排放。7) 试压泵应有专人操作监护，严禁超压。8) 试压应设置禁行区，设置警戒绳，并有专人监护.9) 试压、吹洗作业过程中，严禁随意抛掷工具。10) 试压前应首先观察周围环境，辨别危险源，并采取具有针对性的措施。当施工人员无能力辨别危险源时，应及时与安全专业人员联系，帮助解决。11) 未尽事项，严格执行各级安全要求。9 施工机具及措施用料序号名称规格数量备注1柱塞泵20。0Mpa1台10.0Mpa4台2上水泵219、台3空压机0。6Mpa2台4钢板Q235-B=6mm20m2=8mm50m2=10mm80m2=12mm85m2=16mm90m2=20mm60m2=24mm20m2=30mm30m2520无缝钢管27*4500m604800 m6高压橡胶管6.0Mpa 271000m7消防水带DN50200m8橡胶石棉板=3mm800m2=4mm350m29生料带500盒10闸阀Z61H-40 DN15 16台Z61H-120 DN2012台 Z41H-16 DN508台J61H-40 DN2516台J61H-40 DN2012台11单丝头DN20,SCH80，2076只L=100mm12双丝头DN20，S20、CH80，20#68只L=120mm13压力表0。6 Mpa20只1。0 Mpa24只1.6 Mpa36只2。5 Mpa40只4。0 Mpa48只6.0 Mpa30只10。0Mpa20只16.0Mpa10只14压力表接头72个15塑料桶15个16警戒绳450m17二硫化目200kg18螺栓Q235 M20100010根通丝19螺栓Q235 M24100010根通丝20螺栓Q235 M27100010根通丝21螺栓Q235 M30100010根通丝22螺栓Q235 M36100010根通丝23螺栓Q235 M40100010根通丝10 质量记录：管道系统安装检查与压力试验记录J407。附表1 管21、道系统试压临时盲板安装、拆除记录装置名称： 编号:序号试压包号规格区域位置安装人拆除人拆除时间检查人附表2xx炼油乙烯项目芳烃联合装置主体工艺管道试压系统一缆表1510单元主体工艺管线试压包清单试压包号管线号测试介质 测试压力 (MPa) 备注TP1510-P00021510200-P100015TB1水2.52 1510-40SB10001-2TB1水1510-200-P10002-2TB1水1510-40SB100022TB1水1510-200-P10003-2TB1水1510-200P10004-2TB1水1510-150-P100362TB1水1510-150P10070-2TB1水122、510-150P100712TB1水TP-1510-P00031510-40SB100035TB1水2.52 1510-40-SB100045TB1水1510150-P100055TB1水1510150-P100065TB1水1510150-P100075TB1水1510-150-P100085TB1水1510150-P10009-5TB1水1510150P10010-5TB1水1510-150P10073-2TB1水1510-20P100745TB1水151020P10075-5TB1水TP-1510-P00051510-250P100115TB1水6。68 1510250P10012-5T23、B1水1510-20P10077-5TB1水TP-1510P00071510-40-SB10005-5TB1水6.68 1510-200-P10013-5TB1水1510200-P100145TB1水151080P10016-5TB1水1510-100-P10017-5TB1水TP-1510-P00081510-50SV100225TB1水5.45 1510-50SV100245TB1水1510-150P10039-5TB1水1510-150P10040-5TB1水151080P100415TB1水151080P100425TB1水TP-1510P-0009151050SB10009-5TB124、水6。68 1510200-P100155TB1水1510250-P10035-5TB1水TP-1510-P-00111510-350-P10019-5AD2水6。41510-200-P100205AD2水1510-200-P10021-5AD2水1510200-P100225AD2水TP1510P-00121510200-SV100055AD2水61510-200-SV10006-5AD2水1510-200P10023-5AD2水1510-20010024-5AD2水1510200-P10025-5AD2水1510200P100265AD2水TP-1510P-00141510-50AV10025、015AD2水6。00 1510-40-SV10015-5AD2水1510350-P100275AD2水1510-350P10028-5AD2水1510-350P10029-5AD2水TP1510P-00151510350-P10018-5TB1水5。45 TP1510P-00161510350-P10030-5AD2水5。6TP1510P-00171510-350-P100315TB1水4.38 TP-1510P-00201510-350-P10033-5TB1水4.05 TP-1510-P-00211510-350-P100325TB1水4。05 TP-1510P-0022151080SV26、10016-5TB1水3.96 151080SV10017-5TB1水1510-200-P100345TB1水1510-20-P100805TB1水TP1510P00251510-50-SUD10001-5TB12R水3。96 1510-40SUD100042TB12R水151050SB100105TB12R水1510-20-P10078-5TB12R水151020-P10079-5TB12R水151020P100852TB12R水151020P100862TB12R水TP-1510-P00261510-25P100445TB1水3.96 TP-1510-P-00271510-200P100327、75TB1水3.96 1510200P10038-5TB1水TP-1510P-0028151050-P10043-5TB1水3。96 TP1510-P-00311510-250-P10048-2TB1水2.28 1510-80-P10060-5TB1水1510-150-P10069-2TB1水TP1510P-00321510550-P100475TB1水3。08 1510-450P10049-5TB1水1510-450-P100505TB1水1510-350P10051-5TB1水1510-350-P100525TB1水1510250-P100535TB1水1510250P10054-5TB128、水1510-250-P100555TB1水1510-200P100615TB1水151020P100815TB1水1510-20P10082-5TB1水TP-1510-P00331510300P10045-5TB1水2。22 TP-1510-P-00341510-200SV100262TB12R水2。211510-200-SV10027-2TB12R水1510-250-P100462TB12R水TP1510-P00351510150-P100655TB12R水2.82 1510-150P10066-5TB12R水1510-50P10068-5TB12R水151020P100875TB12R水129、510-20P100885TB12R水TP1510P-00361510-300P100565TB1水2.21 1510-300-P100575TB1水1510300-P10058-5TB1水1510-300P10059-5TB1水TP1510P-00381510200P100632TB12R水2.82 1510200-P100642TB12R水TP1510P-00391510-20P100675TB12R水2.82 TP-1510-P-00401510200-P100622TB12R水2.19 1520单元主体工艺管线试压包清单试压包号管线号测试介质 测试压力 (MPa） 备注TP1520-P30、00011520250-P200012BD4水3。12 1520250P20001/12BD4TP1520P-0002152020-P200652TB1水2.04 1520-150P20001/2-5TB11520150-P20001/3-5TB11520100-P20014/25TB1TP-1520P00031520-1050P20002-5AD1空气1.04 TP-1520P-000415201050-P20003-5AD1TP1520-P00051520-1050P20004-5AD1空气1.04 1520-700P20004/1-5AD1TP-1520-P00061520-1050P231、0005-5AD1空气0。921520-700-P20005/1-5AD1TP1520-P00071520-1050P200065AD1空气0.92TP1520P-00081520-1050-P200075AD1空气0。81TP1520-P000915201050P200085AD1空气0.81TP1520-P-00101520-1050P20009-5AD1空气0.75TP-1520P00111520-1050-P200105AD1空气0.75TP1520P00121520-1200-P200112TB1水2。14 1520-80-P20011/15AD1TP1520-P001315201232、00-P20012-2TB1水4。65 1520-50P20015-2TB11520-50-P20016-2TB11520-150-HG200262TB1TP1520P-00141520250-P200132TB1水4.65 1520250-P20013/12TB1TP1520-P00151520300HG20012-5TB1水4.65 1520-150-P20014-5TB11520150P20014/15TB1TP1520P0016152040-SB20006-5TB1水3。68 152040-SB200075TB11520200-P200175TB1TP1520-P0017152035033、-P20017/1-5TB1水3.68 TP1520-P00181520350P20017/2-5TB1水3.90 TP-1520P-00191520100NR20001-5TB1水3.68 1520-80-SV200135TB11520100SV20015-5TB11520-200P20018-5TB11520-80-SV20013/1-5TB11520-100-SV20015/15TB11520200P20018/1-5TB1TP-1520P00201520200-P200195TB1水3。68 1520-200P200205TB11520-50SV20042-5TB1152050SV2034、043-5TB11520-200P20019/1-5TB1152040-P20019/25TB11520-40P20019/35TB11520200-P20020/1-5TB1TP-1520-P-00211520200P20021-5TB1水2。51TP1520-P00221520150-SV200175TB1水2。03 1520200P20022-5TB11520150-SV20017/15TB1TP-1520-P00231520200-P200232TB1水3。60 152050P20027/22TB1TP-1520-P-00241520-150-P20024-2TB1水3.60 152035、-150-P200262TB11520-150P20024/12TB11520100P20026/1-2TB1TP1520P00251520-100P20025-5TB1水2。55 1520-20-P200715TB1152020P20072-5TB11520100P20025/1-5TB1TP1520-P-0026152080-P20027-5TB1水3。60 152080-P20027/1-5TB1TP-1520P0027152050-SV20019-5TB2水4.54 1520-200P20028-5TB21520-350-P20030-5TB2152050-SV20019/15TB2136、520100P20028/15TB21520-350P20030/15TB2TP1520P-00281520200P20029-5TB1水4。54 1520250-P200315TB21520-20P20069-5TB11520-20P20070-5TB11520-250-P20031/15TB21520-150P20031/25TB21520150-P20031/35TB21520-150-P20031/45TB21520200-P20031/55TB2TP-1520P00291520250P20032-5TB2水2.361520-250P20032/25TB21520250-P20032/37、35TB21520250-P20032/4-5TB2TP1520-P0030152080-P20035-2TB1水2。52 TP-1520P00311520-80SV20023-2TB1水2.40 1520150-P200372TB11520-80SV20023/12TB1TP1520P-00321520150-P200382TB1水2。40 TP-1520-P00331520150P200392TB1水3.60 1520150-P20039/1-2TB1TP1520-P-00341520-100-P20040-5TB1水3。60 152020-P20079-5TB11520-20P2008038、-5TB11520100P20040/1-5TB1TP-1520-P00351520-50P200415TB1水2。70 TP-1520P00361520-250-P200425TB1水2。671520-80-P200445TB1TP-1520-P00371520-300-P200435TB1水2。67TP1520P-0038152080-P20045-2TB1水2。15 TP1520-P0039152080P200462TB1水2。10 152020-P200772TB11520-20-P200782TB1TP-1520P0040152050P20050-5TB1水3.68 152050P239、00515TB11520-20-P200765TB1TP-1520P-0041152050-P20052-5TB1水3.68 1520-50-P200535TB1TP1520-P-00421520-80P200612TB1水1.95 152020-P20073-2TB11520-20-P200742TB1TP-1520P-0043152040-P200622TB1水2.40 1520-15P20062/1-2TB1TP1520-P-0044152020-P200685TB1水3。68 1520-20-P20068/1-5TB11520-20-P20068/2-5TB1TP-1520-P004540、1520-20-P20075-5TB1水3.68 1520-20-P20075/1-5TB11520-20-P20075/25TB1TP1520HG-00461520-200-SV200012TB1水0。68 1520300HG20001/12TB11520200SV20001/12TB11520200SV20001/22TB1TP1520HG-00471520-900HG200022TB1空气0。92 1520750HG20003-2TB1TP-1520HG-00481520-80-HG200045AD1水1。19 TP1520-HG00491520400-HG200062TB1水1.20 41、TP1520-HG-00501520-500HG20007-2TB1水1。20 1520250-HG20007/12TB1TP-1520HG00511520-300HG20008-2TB1水2.33 1520-40-HG200232TB1152040-HG20023/1-2TB1TP1520-HG00521520350-HG20009-2TB1水2.33 TP1520HG00531520-250-SV200052TB1水2.33 1520-400-HG20010-2TB11520250-SV20005/1-2TB11520-250HG20010/12TB1TP-1520-HG00541520242、50HG200115TB1水3。98 1520-200HG20011/1-5TB11520-100HG20011/2-5TB1TP-1520-HG-00551520150-SV200075TB1水3.78 152020AV200082TB11520-80-SV20009-5TB1152080SV200115TB11520-200-HG20013-5TB11520-80HG200255TB11520150-SV20007/1-5TB11520-80-SV20009/15TB11520-80-SV20011/15TB11520200HG20013/1-5TB1TP1520-HG-00561520243、00HG20014-5TB1水3。68 1520-200HG20015-5TB11520-80-HG20016-5TB11520200-HG200175TB11520-50SV20040-5TB11520-50SV20041-5TB11520-200-HG20014/15TB11520100HG20014/2-5TB11520100HG20014/35TB11520-200-HG20017/1-5TB1TP-1520P-0098152080-P20010/1-5AD1水3。90TP1520-HG0099152050-HG20003/1-2TB1水2。33 1520-50-HG20003/2-244、TB11520-200HG20008/12TB1TP1520HG010015201050HG200012TB1空气0.52 1525单元主体工艺管线试压包清单试压包号管线号测试介质 测试压力 (MPa） 备注TP-1525-HG0001152580HG25003-5BD1水4.28 TP-1525HG00021525-80-HG250015BD1水3.01 1525-80HG250025BD1TP1525HG-0003152580SV250015AD1水3.75 1525-80-HG25006-5AD1152540-HG250115TB1152580-SV25001/1-5AD1TP-152545、-HG-00051525-150-HG25005-5AD1水3.07 TP1525HG0006152525P25003-5TB1水5。10 152580HG250125TB1152550-SV25013-5TB11525-80HG250145TB11525-50SV25013/1-5TB1TP1525HG00071525-40NG250042TB11水2.33 1525150-HG25007-5TB11525150-HG250085TB11525-150-HG25010-5TB11525150HG25010/15TB1TP-1525C00081525-100C250255TB6水3。75 1546、25-80-C25026-5TB61525100-C250275TB6TP-1525-C-00091525-200-C250285TB6水2.33 152540C25029-2TB6TP1525C00101525-100-C250015TB6水1。50 1525-90-C25002-2TB61525100-C25004-2BA61525-90-C25005-2TB6TP-1525-C00121525100C250032BA6水0.53 TP-1525C-00151525-100C250205TB6水1.50 1525-25C250245TB6TP-1525-C-00171525-250-C2547、006-2TB1水1.50 TP-1525C00181525-50C250082TB6水1。50 152550-C25008/1-2TB61525-50-C25008/2-2TB6152550C25008/32TB6152550C25008/4-2TB6TP1525C-00191525-50-C250072TB6水1.50 152525C25030-2TB61525-50C25007/12TB61525-50-C25007/2-2TB6152550C25007/32TB61525-50-C25007/4-2TB6TP-1525C00201525-100C250172TB6水1.50 TP15248、5-C00231525100-C25018-2TB6水1.50 TP-1525RG-00291525750-RG250025BD1空气0。52 TP-1525RG-00301525750-RG25001-5BD1空气0。52 TP-1525-RG00331525-100-SV25009-5BD1水1.21 1525200-RG25012-5BD11525-100-SV25009/1-5BD1TP-1525-RG00341525750-RG25007-5BD1空气0。52 TP-1525-RG-00351525-250RG25008-5BD1水1。21 1525200RG25010-5BD11549、25-200-RG250115BD1TP1525-RG-00361525-250RG25009-5BD1水1。21 TP1525-RG00371525200-RG250065BD1水2.98 TP1525IL-00381525-20-IL250012TB1水0.53 1525-20-IL250022TB11525-20-IL25001/1-2BD4TP1525IL00391525-20IL250032BD4水2。70 1525-8-IL25003/1-2BD41525-20-IL25003/2-2BD4TP1525C00401525-100-C250195TB6水1。50 1525100-C250、5022-2BA61525-80C250235TB6TP1525C-00411525-100-C250212BA6水0.53 TP1525-HG-00441525-100HG250185TB1水2。33 1525100-HG25019-5TB11525100-HG250205TB1TP-1525HG00451525-40-SV25011-5TB1水3.75 152580HG25013-5TB11525-25-HG25015-5TB11525-50-HG250165TB11525-80-HG250175TB1152580-HG25021-5TB11525-40SV25011/15TB1TP-1551、25-P-00461525-80P25001-5TB1水3。75 152580P25002-5TB1TP-1525HG00471525-50-HG250042TB1水1.20 TP-1525-CL00501525-200CL250102TB7水0。53 1525150CL25016-2TB7152520CL250172TB7TP1525-CL00511525-150CL25007-2TB7水1.35 1525-50CL250082TB71525-80CL25009-2TB71525-150-CL25012-2TB7152525-CL250142TB71525-50-CL25015-2TB71552、25150-CL25012/12TB7TP1525-RG00531525250RG250142TB15水0。53 TP-1525CL-0055152525-CL25004-2TB7水1.05 1525-25-CL25004/1-2TB7TP1525-CL00561525-40CL25002-2TB7水0。53 1525-40-CL25002/1-2BD1TP-1525CL-00571525-40CL250012TB7水0.65 TP1525-RG-00611525-750RG250035BD1空气0。52 TP1525-RG-00621525-200RG250135BD1水0。92 1525853、0-RG250045BD1水1。44 1525-150-RG25003/1-5BD1水1.44 1530单元主体工艺管线试压包清单试压包号单线图号试压介质试验压力(MPa)备注TP-1530P00331530-150-P300012TB1N水1.81530150P30001-2TB1N1530-50SB30015-2TB1-P1530-20-SB30021-2TB1-P1530100-P300902TB11530100P30091-2TB1TP-1530P00341530150-P30002-2TB1H水1.81530-100-P30084-2TB1TTP-1530P-00351530300P54、300032TB1H水0。53TP-1530P00361530-400-P30004-2TB1H水0。951530-400P300052TB1-H1530-100-P30101-2TB1-H153050-SB300042TB1-NTP-1530P00371530450-P30006-2TB1-H水0。951530-150P30006/12TB1-H1530350-P30007-2TB1-H1530150P30007/1-2TB1H1530-20-SB300282TB1-N153020-SV30029-2TB1N1530-20SV30029/12TB1N1530-20-SV30032-2TB1-55、NTP-1530P-00381530350-P30008-2TB1-P水0.531530150-SV300032TB1P1530150-SV30004-2TB1-P1530-200SV300062TB1-PTP-1530-P00391530-80-P300092TB1-H水0.531530-50P30053-2TB1-TTP-1530-P-0040153050P30010-2TB1-T水0.531530-50-P30011-2TB1T153050-P300532TB1T03-P300971530-50-SB30005-2TB1PTP-1530P00411530-50P30012-2TB1-T水56、2。041530-50P300132TB1T03P-30096TP-1530-P00421530-150P300152TB1-N水0.751530-50-P300592TB1-NTP-1530-P-00431530150-P30016-2TB1N水0.751530-25-P30058-2TB1NTP1530P00441530150-P300172TB1N水1。011530150-P30018-2TB1-N1530-50-SB30006-2TB1-NTP1530-P00451530-100P300192TB1-N水1.01153050P30019/1-2TB1-N1530100P30020-2T57、B1N1530-50P30020/1-2TB1N1530100P30055-2TB1N1530100-P300192TB1-N1530-100-P30060-2TB1-N1530-100P30061-2TB1-N153020-P30100-2TB1N03-P-3009803P30099153020-SB30015/1-2TB1N153020-SB30015/2-2TB1-N1530-20SB300312TB1-N1530-20SB300322TB1-NTP1530-P00461530-250P300215TB1-N水0。831530250-P30029-2TB1-N153050P300722T58、B1-N153025-P30072/1-2TB1-N153050P30073-2TB1-N153025-P30073/12TB1-N1530-50-P30073/22TB1N03-P-3008803P-30089153020-SB30019/1-2TB1-N153020SB30019/22TB1-N1530-20SB30038-2TB1NTP-1530-P-00471530-900-P30022-2TB1P空气0。41530-50P55068A-2TB1-N1530-150-SV300082TB1P1530-150SV300092TB1-P155550P55068A-5TB1NTP1530-P59、00481530-450P30023-2TB1T水3。871530-450-P300242TB1-T1530-80SB300072TB1-TTP-1530-P00491530-20SV300302TB1N水3.871530-150-P30025/15TB1T1530-150-P30026/1-5TB1T1530-20-SV30030/12TB1N1530-250-P300215TB1N1530-300P300255TB1H1530300-P30026-5TB1-T1530-300-P300385TB1T1530-50P30025/2-5TB1-H153050-P30026/25TB1H153060、-50-P30063-5TB1-HTP1530-P-00501530-300-P30027-5TB1-H水3。871530-300-P300385TB1TTP1530P-00511530-250-P30028-2TB1N水0。751530-25P300662TB1N1530-50-P300672TB1-N1530-50-P30072/22TB1N153050-P30073/22TB1-NTP1530P00521530-250P300302TB1-N水1.11530250-P300312TB1-N1530250-P30032-2TB1-NTP-1530P00531530200-P300332TB61、1-N水1.1153080-P30033/1-2TB1-N1530-200P300342TB1-N153080P30034/12TB1N1530-100-P300642TB1N1530-50-P30065-2TB1N03-P300861530-200-P300332TB1-N1530100P30035-2TB1-N1530100-P300612TB1N1530150-P30062A-2TB1N153020-SB30036-2TB1NTP1530-P00541530-300P30036-5TB1H水3。871530250-P300545TB1-H1530-50-SB300185TB1TTP15362、0-P-00551530-300P30037-5TB1H水3。871530-250-P300435TB1-H1530-50SB30019-5TB1TTP-1530P-00561530300P30039-5TB1H水3。871530250P300435TB1H1530250-P30044-5TB1H153050-SB300165TB1TTP-1530-P-00571530-300-P300405TB1-H水3.871530-100-P30045-5TB1-T1530-50P300465TB1-T1530-80-P30085/15TB1-T1530-50-SB30014-2TB1PTP-1530P63、00581530-300-P300412TB-H水3.87153050P300122TB1-T03-P-3009203-P-300931530-20-IL30002-2TB1N153020-IL30005-2BE3T1530-20-SB30022-2TB1-NTP1530P00591530100P300425TB-H水3。87TP1530P-00601530-50-P30046-5TB1T水3。87TP-1530-P-00611530500P30047-25TB1-H水0。651530100-P30101-2TB1HTP1530P00621530800P30048-2TB1H水0.65TP-164、530-P00631530-350-P30049-2TB1H水0。651530350P30050-2TB1-TTP-1530-P-00641530-200P300512TB1-H水0.53TP-1530P00651530-300P30052-2TB1-T水0。951530150P30052/1-2TB1T1530-300-P30056-2TB1-T1530150-P30056/12TB1-T1530-20SB30034-2TB1-N1530-20-SV30031-2TB1N1530-20SV30031/12TB1-N1530-20-SV30035-2TB1-NTP1530-P00661530-65、350P30057-2TB1H水0。95TP1530-P00671530-100-P30064-2TB1N水1.103P-300871530-20-SB30035-2TB1-NTP-1530P0068153080P300692TB1-N水0。53153050P300702TB1N153080-P30071-2TB1-N1530-50P55036A-2TB2T1530-50-SB30006-2TB1-N1530-50-SB30008-2TB1-N153020-SB30033-2TB1-N1530-50TW300012BE3-NTP-1530P00691530-450P300742TB1-H水0。66、531530-450-P300752TB1H1530-350P30076-2TB1HTP-1530P-00701530-100P300772TB1-P水0。53TP-1530-P00711530-100-P300795TB1-T水3.871530-100-P300352TB1-N1530100-P300602TB1N1530100-P30079-2TB1-T1530-100P30081-2TB1N153080P300852TB1-NTP-1530-P0072153080P300852TB1-T水3。871530-80-P30085/1-5TB1-T1530-80-P30085-2TB1T15367、080P30085/1-2TB1TTP1530P-00731530100P30068-2TB1N水0.53153050NG300042TB11-N1530-20-SV300362TB1-N1540单元主体工艺管线试压包清单试压包号管线号测试介质 测试压力 （MPa） 备注TP1540P00011540-650P40003-2TB1空气0.40 TP-1540-P00021540-200-P400072TB1水1。95 1540-150P400102TB11540-20-P400722TB1154020P400732TB11540-200P40007/12TB1TP1540P00031540-268、50-P400022TB1水0.72 TP-1540-P-00041540-100P40001-2TB1水1。05 TP-1540P00051540-50SB400075TB1水3.97 1540150P40019-5TB1水154020-P40074-5TB11540-20-P400755TB1154080-P40018/2-5TB11540150P40019/1-5TB1154080-P40019/2-5TB1154080P40019/35TB1154080-P40019/4-5TB11540150P40019/5-5TB11540150-P40019/6-5TB11540-80-P40069、19/7-5TB11540-150-P40019/8-5TB1154020P40074/1-5TB1TP1540-P00061540-100-SV400195TB1水4.36 1540-150P40063-5TB11540-100-SV40019/15TB1TP1540-P00071540150P40013-5TB1水3。82 154020P400705TB11540-20P40071-5TB11540150P40092-2TB11540150P40013/1-5TB11540-150P40013/35TB11540150-P40047/22TB1TP1540-P-00081540500-P470、0011-2TB1水0。60 1540-250P40012-2TB11540250P40012/1-5TB11540100-P40013/25TB1TP-1540P-00091540-750P40015-2TB1水0。68 TP-1540P00101540-150P40008-2TB1水1。95 TP-1540-P00111540400P400142TB1水0。68 1540-450-P400162TB11540100-P40014/12TB1TP-1540-P-001215401050-P40017-2TB1水0。68 TP1540-P-00131540-200-P40091-5TB1水2.71、40 1540-200P40091/1-5TB1TP1540-P00161540-250P400052TB1水0.60 1540-25P40005/12TB11540-80P40005/22TB11540100-P40013/45TB1TP1540-P-00171540550P40004-2TB1水0.53 TP-1540P0018154050OS40001-2TB2水0。68 1540250P400062TB11540250P40006/1-2TB1TP-1540-P00191540-150-P40009-2TB1水1。95 1540-100P40090-5TB1TP-1540P00201572、40150-P40018-5TB1水5.46 TP1540-P-00211540150P40018/1-5TB1水3。97 TP-1540P-00221540-25-P40023/1-2TB1水2。00 TP1540-P00231540500P40028-5TB1水3.82 1540450-P400315TB11540-20P40080-5TB11540-20P40081-5TB11540500P40028/1-5TB11540-150-P40028/2-5TB11540-25-P40028/3-5TB1154025P40028/45TB11540-250-P40030/2-2TB1TP15473、0-P-00241540250P400232TB1水2。18 TP1540P-00251540700-P400335TB2水5。41 1540-500P400345TB21540500-P40036-5TB21540-300P400385TB21540-300-P400395TB21540200P40040-5TB21540-350P400415TB21540-150P400425TB21540-20P40078-5TB21540500P40033/1-5TB21540-500P40033/2-5TB21540500-P40033/3-5TB21540500P40033/4-5TB21540-74、25P40033/65TB21540-25P40033/75TB21540-25P40033/8-5TB21540150P40034/15TB21540-150-P40034/105TB21540-150-P40034/115TB21540-150-P40034/125TB21540-150-P40034/2-5TB21540150P40034/35TB21540-150P40034/4-5TB21540150-P40034/5-5TB21540150-P40034/6-5TB21540150-P40034/75TB21540-150-P40034/85TB21540-150P40034/9575、TB21540150-P40036/15TB21540150P40036/10-5TB21540-150P40036/11-5TB21540-150-P40036/12-5TB21540-150P40036/2-5TB21540150-P40036/35TB21540-150-P40036/45TB21540-150P40036/55TB21540150P40036/65TB21540-150-P40036/7-5TB21540-150P40036/8-5TB21540150-P40036/9-5TB2154080-P40042/1-5TB2TP-1540P-00261540900P4003776、5TB2水2.16 1540200-P40037/15TB21540200P40037/10-5TB21540-200P40037/115TB21540200P40037/125TB21540-200P40037/2-5TB21540-200-P40037/3-5TB21540-200-P40037/45TB21540200P40037/5-5TB21540200-P40037/6-5TB21540-200-P40037/7-5TB21540-200-P40037/8-5TB21540200P40037/9-5TB2TP-1540P-00271540900P40035-5TB2水2。16 1577、40200P40035/15TB21540-200P40035/10-5TB21540200P40035/11-5TB21540200-P40035/125TB21540200P40035/2-5TB21540-200P40035/35TB21540-200P40035/4-5TB21540200-P40035/5-5TB21540-200-P40035/6-5TB21540-200P40035/7-5TB21540-200P40035/85TB21540200-P40035/95TB2TP-1540-P00281540-200-SV400072TB2水2。00 TP1540P0029154078、-700-P40027-2TB1水2.18 1540700P40027/12TB1TP1540P00301540-450-P40029-2TB1水5.27 1540-300-P400305TB11540-20-P40083-5TB1154020P40084-5TB11540-450P40029/1-2TB11540-300P40030/1-5TB1TP1540-P-00311540-900P40032-5TB2水4。20 1540-20-P400795TB21540-700-P40032/15TB21540700-P40032/2-5TB21540700-P40032/35TB2TP1540-79、P00321540-200P400205TB1水3.25 154040-P40062-5TB21540-20P400765TB21540200P40020/1-5TB1154040P40062/15TB2TP-1540-P-00331540-50P400615TB2水3.25 154020P400775TB2TP-1540P00341540700P40097-2TB2水0。74 TP1540-P-00351540-100-SV400155TB1水5.30 1540600P400432TB11540-100SV40015/1-5TB1TP-1540-P-00361540600-P40044-2T80、B1水1.20 TP-1540P-00371540250P40045-2TB1水0.60 154025-P40045/1-2TB1154080-P40045/22TB11540-80-P40059/35TB2TP1540-P-00381540-200-P400472TB1水2。19 1540150P40048-2TB11540-150-P40052-2TB1154020P40086-2TB11540-20P400872TB11540200-P40047/12TB1TP-1540P-00391540-80SV400212TB1水2.19 1540-250-P400462TB11540150P4081、049-2TB1154080-SV40021/1-2TB11540-250-P40046/1-2TB1TP1540P00401540150P400502TB1水2。19 1540-150-P40050/1-2TB11540-150-P40050/22TB1TP1540-P-00411540-150-P40057-2TB1水3。15 1540-80-P40059-5TB21540150-P40050/3-2TB11540150-P40064/1-2TB1TP1540-P-00421540100-P40054-2TB1水0。70 1540-50P40054/1-2TB11540-25-P4005482、/2-2TB1TP1540P00431540-80/40SV400232TB1水1。80 1540-80-P40056-2TB1154020P400882TB1154080SV40023/12TB11540-80P40056/1-2TB1154080-P40056/22TB1TP-1540-P00441540-100-P400552TB1水1。80 154020-P400892TB11540-100P40055/1-2TB1TP1540-P00451540250P400532TB1水0.70 1540-80P40053/12TB1TP1540P0046154080-P400602TB1水2。583、2 154020P40085-2TB1154050-P40060/1-2TB11540-20P40085/12TB1TP1540-P00471540350P400582TB2水2.54 1540350-P400962TB21540-100P40058/1-2TB21540-80P40059/15TB2154080-P40059/25TB2TP1540-P00481540-150-P400645TB1水3.15 1540150P400952TB1TP-1540P00871540-1150P40024-2TB2空气1。27 TP-1540P00881540-1200-P40021-2TB2空气1.84、27 TP-1540P00891540-500-P40022-2TB2水2。00 1540350-P40025-2TB21540-200P400262TB21540200-SV40007/12TB21540-200-SV40007/22TB21540200-SV40007/32TB21540-450P40033/55TB21550单元主体工艺管线试压包清单试压包号单线图号试压介质试验压力(MPa）备注TP-1550P-00011550200P50049-2TB1N水2.671540200-P40047-2TB1-H1550-200P50048-2TB1-N1550200P50050-2TB1-85、N1550-200-P50051-2TB1-NTP1550-P00021550300-P500012TB1-H水7。851550-300P50002-2TB1H1550-20P50072-11TB1-PTP1550P0003155020P5007111TB1P水7.851550250-P5000311TB1-H1550150P50054-11TB1-H1550250P5000411TB1-H1550250-P5000611TB1HTP-1550-P00041550-80SV500032TB1-N水1。8155080-SV500012TB1P1550-150P500572TB1N1550-20P86、500852TB1N1550-20P5008625B1-N1550-150P50057-2TB1NTP1550-P-00051550-500-P50009-11AD2H水10.241550-150P50009/111AD2H1550-150P50009/211AD2-H1550150P50009/311AD2-H1550-150-P50009/4-11AD2-H1550150P50009/5-11AD2-H1550-150-P50009/6-11AD2-H1550-150-P50009/711AD2-HTP1550-P00061550-600-P5001111AD2H水9。731550-15087、-P50011/1-11AD2H1550-150-P50011/211AD2H1550150P50011/311AD2-H1550150-P50011/4-11AD2-H1550-150P50011/511AD2H1550150P50011/6-11AD2H1550150-P50011/711AD2-HTP-1550P00071550-150P500412TB1H水1。96TP-1550P00081550-150-P50039-5TB1H水2。961550-150-P50040-5TB1HTP1550P00091550-250P50007-5BG1-H水7.89TP-1550P-001015588、0-400P500235TB1H水5。93TP-1550P-00111550600-P5001311AD2-H水9。73TP-1550P00121550-500P500145TB1H水5。18TP-1550-P-00131550-250-P50016-5TB1H水5.181550-150-P500205TB1NTP-1550-P-00141550-450-P500185TB1-N水5.1TP-1550P-00151550-450P500195TB1-T水4.95TP1550-P-0015A1550-450-P500175TB1-N水5。18TP-1550P00161550150-P50021589、TB1-N水4。95152080HG20016-5TB1-DTP1550P00171550-500P50015-5TB1-P水5.931550-200P500245TB1-PTP-1550P-00181550300P500302TB1H水2。1TP-1550P-00191550-80-P50065-5TB1-N水3.751550200HG20015-5TB2NTP1550P0020155040-P50062-5TB1N水5.99155040P50063-5TB1N155080P50064-5TB1N155020-P50080-5TB1N1550-20-P500805TB1-N1550-40-P90、50079-5TB1N1550-150-P500275TB1H1550150-P500285TB1H1550200P50025-5TB1T155050-SV500165TB1-N155050-SV500135TB1NTP1550P00211550200P500345TB1H水5.391550-150P50070-5TB1H1550200P500365TB1H1550-200-P50035-5TB1H1550-20-P50081-5TB1P155020-P500825TB1P1550-200-P500365TB1-HTP-1550-P00221550-600-P500682TB1-H水1.95T91、P1550-P00231550-300P50032-2TB1H水5。391550-250P50032-2TB1-H1550200P500372TB1-H1550-200-P50038-2TB1HTP-1550-P00241550-450-P50067-2TB1-H水1。95TP-1550-P00251550350P500312TB1P水1.65TP-1550P-00261550-150P500602TB1N水5.9TP-1550P-00271550350P500695TB2H水3。85TP-1550P-00281550-150P500475TB1-N水2。671550-20-P50083-5T92、B1-N1550-150P50042-5TB1NTP-1550P-00291550200-P500452TB1N水2。671550-20P50084-2TB1NTP1550P-00301550-50P500592TB1-N水1。65TP1550P00311550-250P500442TB1N水2.67TP-1550P0032155050P500582TB1-N水1。65TP-1550P-00331550250P500432TB2N水1。65TP1550-P-00341550-250P500202TB1H水4.95TP-1550P00351550150P50052-2TB1-N水7.85155593、单元主体工艺管线试压包清单试压包号单线图号试压介质试验压力（Mpa)备注TP-1555P00011555-150-P55003-5TB1-N水3。91555-200P550035TB1-N1550200P50036-5TB1-HTP1555-P-00021555150-P550625TB19T水1.81555-100P550225TB19-TTP1555P-00031555200-P550075TB1-H水3。9TP1555P00041555-80-P55066-5TB1-P水4。3155580P550675TB1-P1555-80-P550835TB1-PTP-1555P000515552094、0-P550145TB1H水4.241555200-P55013-5TB1HTP-1555-P-00061555-200P550155TB1H水3。91555300P550155TB1HTP1555-P-00071555-650P55027-2TB19-P水0。53TP1555P-00081555-200P550332TB19N水1。95155520P550772TB19-T155520-P55078-2TB19P1555-200-P55034-2TB19-T155550P550352TB19TTP-1555P-00091555-150-P550162TB19P水0。975TP-1555P0095、101555600P55056-2TB1H水0。9751555-400P55037-2TB1-P1555200SV550332TB1P1555200SV550352TB1-P1555-200-SV55037-2TB1P1555-700P550372TB1H1555250P55057-2TB1HTP-1555-P00111555200P55003/1-5TB1H水3.9TP1555-P-00121555200-P55011/1-5TB1H水4.24TP-1555P00131555150-P55040/1-5TB1-N水2。85TP-1555P-00141555-300-P55058-2TB1-P96、水0.975TP1555-P-0015155525-P55061-2TB1-P水0.9751555-25-P55065-2TB1P1555200-P55044-2TB1P155550-P550642TB1-PTP1555P00161555200-P55025-2TB1H水1。951555-200P550262TB1-HTP-1555-P-00171555250P55024-2TB1H水0。5251555250-P55023-2TB1-HTP-1555P00181555-150P55017-2TB19-N水1.65155520-P55076-2TB19T1555150P550182TB19-T197、55520P550222TB19T1555100-P55020-2TB19-T1555-20-P550752TB19T1555-100P55019-2TB19N1555100P550192TB19-TTP1550P-00191555-250P55032-2TB19-T水0.61555250P55031-2TB19NTP-1550-P00201555-25-P550302TB19-T水0.531555250-P550282TB19N155580-P55029-2TB19NTP-1555P00211555150P55025/1-2TB1-N水1.95TP-1555P-00221555-200P5598、0632TB1-P水2。4155520P550825TB1-P1555-20P55081-5TB1-P1555-250-P55047-5TB1-H1555-200P550475TB1H1555250-P550485TB1-H1555-150P55047-5TB1P1555200P55049-5TB1-HTP1555-P-00231555350-P550452TB1-H水0.975TP-1555P-00241555700P55055-5TB1-H水1.211555-700P550535TB1H1555150P55053/15TB1-H1555150P55053/25TB1-H1555-150-P99、55053/35TB1-H1555-150P55053/45TB1H1555150P55053/5-5TB1-H1555150P55053/6-5TB1-H1555-150-P55053/7-5TB1HTP1555P-00251555-150-P55085-5TB1P水3。331555350-P550405TB1-HTP-1555P00261555-150-P55040-5TB1-H水3.331555-20P550795TB1P1555350P550415TB1-H1555300-P550525TB1H1555150P55052/1-5TB1H1555-150-P55052/25TB1H155100、5150-P55052/35TB1H1555150-P55052/4-5TB1H1555-150P55052/55TB1-H1555-150-P55052/6-5TB1H1555150P55052/75TB1HTP-1555P00271555-450P550392TB1H水3。331555-20P55080-5TB1P1555450-P550382TB1HTP-1555P00281555100-SV550445TB1N水2。41555-100SV550435TB1-N1555-150P55050-5TB1-NTP-1555-P-00291555-150P55051/15TB1N水2。41555101、-150P55051-5TB1-N1555200-P550495TB1-HTP-1555P0030155550-P55036-2TB2T水0。61560单元主体工艺管线试压包清单试压包号管线号测试介质测试压力 (MPa)备注TP1560P00011560-200P60001-5TB1水4.35 1560200P60002-5TB11560-200P600355TB11560200-P660015TB11560200-P660025TB11560200-P660355TB11560-200-P60001/15TB11560200P60002/1-5TB11560-150P60002/25TB11102、560200-P60035/15TB11560200P66001/15TB11560200-P66002/1-5TB11560-150-P66002/2-5TB11560200-P66035/15TB11570-300P700435TB2TP-1560-P00031560-200P60082-2TB1水1。67 156050-P600862TB11560-20-P60175-2TB11560200-P60082/12TB1TP1560-P00041560-150P600832TB1水1。67 1560-50-P600842TB11560-20-P601742TB11560150-P60083/103、12TB1TP1560P00051560100-P60130-2TB1水1.81560-20P601822TB11560100-P60130/1-2TB1TP1560-P00061560-80-P601312TB1水1.95156040P601442TB1156020P60181-2TB1156080-P60131/12TB1156050-P60131/22TB1TP1560P-00071560-500P600392TB1水1。95 156020-P60167-2TB11560500-P60039/1-2TB1TP1560P00081560-350-P60040-2TB1水1。95 1560-104、20-P60166-2TB11560-350P60040/12TB1TP-1560-P00101560-350-P60051-5TB1水4。85 1560-250P60052-5TB11560-250P600535TB1156080P600545TB11560-40P60055-5TB11560-40P600565TB1156050P60057-5TB1156050P60058-5TB1156080-P60059-5TB11560150-P60085-5TB11560-250-P601065TB11560250-P601075TB11560250-P660515TB11560-250P6605105、25TB11560250-P660535TB11560-80-P66054-5TB1156040P660555TB1156040P660585TB11560-80-P660595TB11560150-P66085-5TB11560250-P661065TB11560-250-P661075TB11560150-P60050/2-5TB11560150P60051/15TB11560250P60052/1-5TB11560-250-P60053/15TB11560200P60053/25TB11560-80P60059/15TB11560-250P66052/15TB11560-250P6605106、3/1-5TB11560-200-P66053/25TB11560-40-P66057/1-5TB11560-80P66059/15TB11560-40-P66105/15TB1TP1560-P-00111560300-P60030-5TB1水2。40 1560300P600325TB11560300-P60030/1-5TB11560300P60032/1-5TB1TP1560-P00121560250P601102TB1水0。73TP1560-P00131560-200-P600422TB1水0.60 TP-1560P-00141560-400-P60041-2TB1水2.10 15601107、50P600952TB11560150P601082TB1 1560-150-P601472TB11560-150P601482TB1156020-P601642TB11560-20-P601652TB11570-200P700492TB1156020P601722TB1TP1560-P00151560200SV60018-5TB1水4.65 1560-200-SV60020-5TB11560-200SV60022-5TB11560-200SV600245TB11560-300P600315TB11560300-P600335TB11560-300P60031/15TB11560-300-P6108、0031/2-5TB11560300P60033/1-5TB11560-300P60033/2-5TB1TP1560-P0016156020-P601625TB1水5156020P60163-5TB1TP1560P00171560-100P601355TB1水2.85 1560-250P601385TB11560-250-P60139-5TB11560-250-P601405TB1TP1560-P00181560150-P60003-5TB1水2。85 1560150-P600045TB11560-150P600055TB11560-150P600065TB11560150-P60007-5T109、B11560150P600085TB11560150P600095TB11560-150P600105TB11560-150-P600115TB11560-150P600125TB11560150-P60013-5TB11560150-P600145TB1TP1560-P-00191560-80-SV600265TB1水5.22156080-SV60027-5TB11560-50SV600315TB11560200-P600495TB11560-200-P60074-5TB1156080-P60102-5TB1156080-P601035TB1156020-P60168-5TB11560200110、-P60049/1-5TB11560200P60049/2-5TB11560-200-P60049/3-5TB11560250P60049/45TB11560200-P60074/15TB1TP-1560-P00201560-150P60015-5TB1水2.85 1560150P600165TB11560-150-P60017-5TB11560150P60018-5TB11560150P600195TB11560150-P600205TB11560-150-P600215TB11560150P60022-5TB11560150P600235TB11560-150P60024-5TB11560111、150P60025-5TB11560150-P60026-5TB1TP1560P00211560-200SV60021-2TB1水2.85 1560200P60027-5TB11560100-P600285TB11560-100P60028/15TB1156080P60028/25TB1TP-1560-P00221560100-P60029-5TB1水3。75 1560100-P60029/15TB11560-80P60029/25TB1TP1560-P-00241560-250P60050-5TB1水51560200P600755TB11560150-P60119-5TB11560-150P112、601415TB1TP1560P-00251560200SV60025-2TB1水3。88 1560-400-P60063-5TB1TP1560P0027156080SV600435TB1水4。80 1560-80SV60044-5TB11560-250-P601365TB1TP-1560-P-00281560-200P600812TB1水0。68 1560-50P60081/12TB1156025-P60081/2-2TB1TP-1560-P00291560150P60070-2TB1水0.84 TP-1560P00301560-50P60071-2TB1水0.84 156025P60071113、/1-2TB1156025-P60071/2-2TB1TP1560P00311560-80SV600302TB1水0.811560100SV600352TB11560-100SV600422TB1156050-P60072-2TB1156050P60072/1-2TB11560-25P60072/3-2TB1TP1560P00321560-450P60038-2TB1水0。68 1560450-P60038A-2TB11560-450P60038B-2TB11560450P60038C-2TB11560450-P60038D2TB1156025-P60038/12TB11560150-P600114、38/22TB1TP-1560P-00331560-50P60060-5TB1水3.54 1560-50P600615TB1156050P60105-5TB11560-20-P60132-5TB1156020-P60133-5TB1156020-P601505TB11560-20-P60151-5TB11560-20P60152-5TB11560-20P60153-5TB1156020-P601585TB1156020-P601595TB1156020P60160-5TB1156020-P601615TB1156020-P60185-5TB11560-40-P60056/15TB11560-4115、0P60056/2-5TB11560-40-P60057/1-5TB1156040-P60057/2-5TB1156040-P60060/1-5TB11560-50P60061/15TB1156040P60105/15TB1TP-1560-P-00341560600-P60044-2TB1水1。441560-150-P60050/15TB1TP-1560P-0035156040-P60044/1-2TB1水1.441560-40-P60044/22TB1156020-P60044/32TB11560-20P60044/4-2TB1TP-1560-P-00361560600-P60046-2TB116、1水1.44TP-1560P003715601300P60047-2TB1水1.45TP-1560-P-003815601300P600452TB1水1。45TP1560P-00391560-600-P600365TB1水3。82TP1560-P-00401560-25-P60115/1-2TB1水1.991560-25-P60115/2-2TB1156025P60115/32TB11560-25-P60116/12TB11560-25-P60116/22TB1156025-P60116/3-2TB1156025-P60118/12TB11560-25-P60118/2-2TB1156025-117、P60118/3-2TB1TP-1560-P-00411560-300P600732TB1水4。51560-500-P60076-2TB11560-20-P601695TB11560-300P60073/12TB11560-100-P60073/22TB11560150P60074/2-5TB1TP-1560-P00421560800-P600772TB1水1。34TP1560-P-00431560800-P600782TB1水1.34TP1560-P00441560-450P60115-2TB1水2。181560-450-P601162TB11560-400-P601182TB1154025118、0P400232TB1TP-1560-P00451560-100-P660285TB1水2.85 1560100-P66028/15TB11560-80-P66028/25TB1TP-1560P00461560-100P661355TB1水2.85 1560250P661385TB11560-250P661405TB11560-300P66030/15TB11560300-P66032/1-5TB1TP1560P00471560-300P660325TB1水2.40 TP1560-P-00481560-50-P660575TB1水4.50 TP1560-P-00491560-300-P6603119、0-5TB1水2。40 TP1560P00501560-250P661395TB1水2.85 TP-1560-P00511560150P600922TB1水2。10 1560150-P60092/1-2TB1TP-1560P-00521560-300P600662TB1水1。80 1560-200P600672TB11560150-P60068-2TB1156020-P601702TB11560-20P60171-2TB11560300-P60066/12TB1156050-P60066/2-2TB11560200P60067/12TB1TP1560-P00531560300-P60087-2120、TB1水2。10 1560-250-P60089-2TB11560-450/200-P60091-2TB1156020-P60173-2TB11560-20P601872TB11560-200-P60091/12TB1TP-1560-P00541560-1400P60037-2TB1空气0。461560-1400P60037/1-2TB11560350-P60037/2-2TB11560350-P60037/32TB11560-350-P60037/42TB11560350P60037/5-2TB11560350-P60037/6-2TB11560350-P60037/7-2TB11560-3121、50-P60037/82TB11560350P60037/9-2TB1TP1560P-00591560-40-P600792TB1水1。85156020P60079/12TB1TP-1560-P-00621560150P66003-5TB1水2。85 1560150-P66004-5TB11560150-P660055TB11560150-P660065TB11560-150-P66007-5TB11560-150-P66008-5TB11560150-P66009-5TB11560-150-P660105TB11560150-P660115TB11560150P660125TB1156015122、0-P66013-5TB11560150-P660145TB1TP-1560P-00631560150-P660155TB1水2.85 1560-150P66016-5TB11560-150-P660175TB11560-150P660185TB11560-150P66019-5TB11560-150P660205TB11560150-P660215TB11560150P66022-5TB11560150P66023-5TB11560150-P66024-5TB11560150-P66025-5TB11560150P660265TB1TP-1560P00641560200P60062-5TB1123、水3.60 156020P601565TB11560200-P660625TB1156020-P66156-5TB11560150P60062/15TB11560150-P66062/15TB1TP-1560-P-00651560250P60034-5TB1水3。54 156020-P601545TB11560-200-P60034/15TB1TP1560P-00661560-200-P60121-2TB1水1.80 1560-200P601232TB11560200-P60125-2TB11560-20P601572TB11560-100P60121/1-2TB11560200-P60123124、/12TB11560-200P60125/1-2TB11560100P60125/2-2TB1TP-1560P00671560200-P60124-5TB1水1。80 1560150-P601262TB11560-150P601272TB1156020P601552TB11560-150P60126/1-2TB1TP1560-P-0068156050-P60122-2TB1水0。75 TP1560-P-00691560100-P601292TB1水1。05 TP-1560P00701560150-P60120-5TB1水4。50 TP-1560P00711560200P60098-2TB1水1125、。20 1560200-P600992TB11560200P60100-2TB1156020P601792TB11560-200-P66100-2TB1TP-1560-P-00721560250P600962TB1水1。20 1560100-P600972TB11560-20-P601782TB11560-250P66096-2TB11560-100P66097-2TB1TP1560-P00731560200P60192-5TB2水5。09TP-1560-P-00741560200P601092TB1水1.371560-50-P601112TB2156020P60176-2TB21560-25126、P601912BD4 TP-1560P-00751560-50-P601122BD4水1。66156020P60177-2TB2156025P60190-2BD4 TP1560P-00761560100P601282TB1水1.11156020P601832TB11560-50P60200-2TB1TP-1560-P-00781560200SV600392TB1水0.60 1560600-P60080-2TB11560-80-SV60037/1-2TB1TP1560P00791560500P60088-2TB1水1.77 TP-1560-P00801560450-P60090-2TB1水0。6127、8 TP-1560-P00821560-200-SV60019-2TB1水0。75 1560300-P601342TB1TP-1560-P-0084156040-P66056-5TB1水4.50 1560-50P66060-5TB11560-50-P661055TB1156020P661325TB11560-20-P66150-5TB1156020P661515TB11560-20P66152-5TB11560-20P661535TB11560-20P661585TB11560-20P66159-5TB11560-20-P661605TB1156020P66161-5TB1156020P661128、85-5TB1156040P66056/15TB11560-40P66056/25TB1156040P66057/2-5TB11560-40-P66060/15TB1TP1560-P-00851560-200SV66018-5TB1水4.65 1560200-SV660205TB11560300P66033-5TB11560-300-P60033/25TB11560-300-P66033/1-5TB1TP1560-P00861560200SV660225TB1水4.65 1560200SV66024-5TB11560300-P66031-5TB11560-300-P66031/1-5TB115129、60-300P66031/25TB1TP-1560-P-0087156040SV60013-5TB1水3。54 1560-50P66061-5TB11560-40SV60013/1-5TB11560-50-P66061/15TB1TP1560-P-00881560100-P601015TB1水3。54 TP1560-P-00891560200P60062/2-5TB1水3.60 1560200-P66062/2-5TB1TP1560-P00901560-150P60143-5TB1水4。77TP1560P00911560150-P601495TB1水4.50 TP1560P00921560-1130、50P60074/35TB1水5。02TP-1560P00931560150-P60145-2TB1水4。43 TP-1560-P00941560-200SV60033-2TB1水0.60 1560-200-SV60034-2TB1TP1560P-00951560-300-P60065-2TB1水0。68 1560-25P60065/1-2TB1156080-P60065/2-2TB1TP1560-P-01001560150-P60093-2TB1水2.10 1560150-P601462TB1TP-1560P01021560150-P60069-2TB1水1.80 TP1560-P-0104131、1560-200-P60108/1-2TB1 水2.10 TP-1560P-01051560-200-P60186-2TB1水2.40 TP-1560P-01061560-20P661335TB1水2.40 TP1560P-01071560200P660275TB1水3。54 1560-250P660345TB11560-20-P661545TB11560200P66034/15TB1TP1560P-01081560100P66029-5TB1水3.75 1560-100P66029/1-5TB11560-80-P66029/25TB1TP1560P-01091560-300-P60104-2132、TB1水0。67TP1560P01161560300-P60048-2TB1水0。761560450-P60048/12TB11560-300P60048/22TB11560-100P60048/3-2TB1TP1560P-01171560-900-P60064-2TB1空气0。461570单元主体工艺管线试压包清单试压包号单线图号试压介质试验压力(MPa)备注TP-1570P-00011570-1100P70005-5AD2H空气2.13TP-1570-P-00021570-400P70032-2TB1H水1.81570-250P70032/1-2TB1H1570250P70032/22TB133、1-H1570-250P70032/325B1HTP-1570-P00031570-200-P700295TB1-H水1。431570-150-P70029/15TB1H1570-150-P70029/25TB1-H1570150P70029/3-5TB1H1570-150-P70029/4-5TB1-HTP1570P00041570-1050-P70004-5AD2H空气2。24TP1570-P00051570-1100P70006-5AD2H空气2.13TP1570-P-00061570250P70003-5TB1-H水4。121570200P70002/2-5TB1-H1570250-P134、700025TB1-H1570-250P70003-5TB1-H1570-150P70003/35TB1HTP-1570P-00071570-250P700135TB1-N水4.81570-200-P70003/15TB1-HTP1570P00081570-250-P70003/55BD4-H水4。81570-250-P70003/65BD4HTP-1570-P00091570-1000-P700075TB1-P水2。931570400-P70011/1-5TB1-P1570300P70011/15TB1PTP1570P00101570-950P700082TB1-N水2.63TP1570P0135、0111570400-P70012-2TB1-N水3。751570-250P70013/25TB1-NTP1570P-00121570250-P700135TB1-N水3.75TP-1570P00131570-1050P70009-2TB1T水2。651570150-P700462TB1-N1570150P70010-2TB1-NTP1570P-00141570250P700145TB1H水3。84TP1570-P-00151570250P70002/15TB1H水4.81570-250P70048-5TB1-HTP1570-P-00161570-20-P700535TB1-P水3。84157136、0-150-P700365TB1-H1570-250P700355TB1-HTP-1570-P-00171570150-P70034/2-5TB1H水3。881570-250P700345TB1-H1570-80P70034/2-5TB1H1570-150P70034/45TB1-HTP1570-P00181570250-P70034-5TB1H水3.881570-250-P70034/3-5TB1HTP1570P-00191570-20P70055-5TB1P水4。021570-250-P70031/15TB1-H1570-250P700315TB1-HTP1570-P00201570300137、P700165TB1-H水3.71TP1570P-00211570-250P700155TB1H水3.48TP-1570P00221570300-P70028/1-2TB1H水1.091570400P700302TB1-H157020-P70056-5TB1-N1570400P70030/12TB1HTP-1570-P00231570150-P70044-2TB1P水0.91570450P700172TB1PTP1570P00241570600-P70026-2TB1-H水1。09TP1570P00251570600-P700272TB1-H水1.09TP1570P00261570150-P7138、00222TB1-N水2。131570-150-P700222TB1-NTP-1570P-00271570-350-P70018-2TB1N水0。91570350-P70018/12TB1NTP1570-P-00281570-80P700212TB1-R水2。13TP1570-P-00291570-150-P700202TB1-N水2。13TP1570P00301570-250-P70019/1-2TB1-N水0.9TP-1570P00311570-150P700242TB1-N水1。81570-20P700592TB1N1570150-P70024/12TB1NTP1570P-00321570-50-P70024/22TB1N水1。8TP1570P00331570250P70023-2TB1-N水1。81570-250P70023/12TB1N157020P700602TB1NTP-1570P00341570-20-P70061-2TB1-N水1。681570-20-P70062-2TB1-N157050-P70042-2TB1-NTP-1570P00351570-80-P700402TB1P水0.91570-80-P70041/12TB1-PTP-1570P00361570-200P70039-2TB1H水0.9